5 Major TYM Tractor Problems & How To Troubleshoot Them

As far as agricultural machinery goes, TYM has evolved as one of the largest, most respected global tractor manufacturers in the world, and for a good reason. TYM machinery is well-made and dependable. But no matter how well-made a machine is, it will inevitably age and wear down with usage, and TYM tractors are no exception to this rule.

As the years go by, you may be faced with TYM tractor problems yourself. If that’s the case, worry not.

In our thorough guide, we’ll discuss the top five major TYM tractor problems — namely horrible smells, the fuel burning too fast, the battery draining too fast, dull blades, and noisy transmission systems — as well as how to troubleshoot them successfully.

Let’s take a closer look at these major TYM tractor problems.

5 Major TYM Tractor Problems & How to Troubleshoot Them

Although TYM makes an impressive, worthwhile tractor, there are also a couple of issues that many TYM tractor owners face at some point or another. Most are almost inevitable and depend on your tractor’s age and how often you use it.

Some of the most common issues you could face include:

• An engine that smells horrible
• An engine that burns fuel too fast
• A battery charge that doesn’t last
• Dull blades
• A noisy transmission system

Starting from the top of the list, let’s take a more in-depth look at why you might smell an awful odor coming from your TYM tractor engine.

Problem #1: Your TYM tractor engine is releasing a foul smell.

This is probably the most obvious issue on our list. It’ll be hard to miss if your TYM tractor engine is producing a nasty smell.

If your tractor’s engine is releasing a foul smell, you can trace this back to either bad or stale gas and lubricant, or a fuel system that’s malfunctioning. Occasionally, the foul smell could be from gas leaks, the filter being blocked by debris, or fuel pressure handicaps, but this is less common.

To fix this, start by cleaning the entire fuel system thoroughly. Remove any grime, debris, or dirt that’s built up over time in the system. You can also buy specialty cleaners to ensure it gets the job done.

Changing the oil can help too. Make sure to never use old or stale gas, as this can wreak havoc on your engine over time and — as you guessed — cause a horrible smell. For example, if you use low grade oil, keep in mind that it’s usually mixed with alcohol. When this burns, it causes a very foul smell. On top of that, it can ruin your tractor eventually. Fresh, new fuel is what your tractor needs. You should also make sure the lubricant you’re using is of good quality.

Problem #2: Your TYM tractor is burning fuel too fast.

Many TYM tractor owners have mentioned issues with fuel burning too fast. If you’re also experiencing this, it’s pretty commonplace, unfortunately.

Although TYM makes an excellent tractor, most people agree that the fuel economy technology used is not very impressive, nor sufficient at all times. To combat this, you can examine other areas of your tractor to slow down the tractor’s fuel burning rate.

Believe it or not, the answer could lie in your tires. By optimizing your tractor’s tire pressure, you can actually save fuel in turn.

If your tires are very inflated and you’re driving your tractor on hills to the point where it needs more grip, you’re actually using more fuel. The tractor needs more grip, which means more power, which means more gas burned.

It’s the same for the opposite situation. If you’re driving on roads while your tires aren’t inflated correctly, you’ll burn fuel much faster.

You can also reduce your tractor’s fuel burning speed by taking your tractor to shallower areas. For example, if you’re working in areas that are very deep, you’ll be using more fuel and will notice the gas burning quicker.

Problem #3: Your TYM tractor’s battery is draining too fast.

You might notice one day that your TYM tractor isn’t lasting as long as it used to. In other words, the battery’s charge is draining too fast.

To figure out why this happens, let’s look at what’s going on inside. Your tractor uses a battery so that it can both store and transfer electrical energy to other components. In order to run, the tractor needs this electrical energy, as well as the plethora of electrical circuits your TYM tractor has.

In some capacity though, it’s only normal for your tractor battery to weaken over time, especially with continuous usage over the years. Not only will the battery itself weaken, but also the tractor’s connectors and circuit parts. These will degrade and affect how your battery holds a charge (or its ability to charge at all).

If you suspect a battery drain, go ahead and use a wrench to detach the ground battery cable. If you don’t have battery cleaning tools, consider buying some special cleaning tools so you can best clean the terminals of the battery cable.

If you have one, grab a test light. Connect the alligator clip of the test light to the battery cable terminal. Once it’s connected, wait to see if you can spot a glowing light. If so, you can confirm you have a battery drain. 

As for the culprit, it depends. To determine the faulty part, you can use the test light while you disconnect and reconnect circuit parts and wires. With this tool, you’ll be able to check all the common culprits: the alternators, the ignition switch, the solenoid, etc.

You’ll know you found the right culprit if your test light goes out during your testing of these tractor parts. Depending on the faulty part, you can sometimes repair it, but more often than not, you’ll have to replace the part with a new one.

Problem #4: Your TYM tractor’s blades aren’t sharp enough.

A tractor’s blades are arguably one of the most crucial parts. After all, a tractor can’t do its job properly without sufficiently sharp blades.

Over the years, you might notice your TYM tractor’s blades aren’t doing the job. It’s probably because they’ve lost some of their edge. In other words, the tractor’s blades have worn down.

Don’t worry: This is totally normal and expected. Luckily, it doesn’t mean you have to toss your blades out. Usually, you can just give them a quick sharpening and get back to it.

For the majority of folks, you’ll only need to touch up the blades’ sharpness about twice per year. However, how often you sharpen the blades will depend on how often you use your tractor. The sharpening process will also vary depending on the size of your TYM tractor model. For example, a bigger tractor could require outside help for sharpening blades, whereas a smaller model usually just needs a file to sharpen the blade, since they have a single-blade mowing deck.

Problem #5: Your TYM tractor has a noisy transmission system.

TYM tractors aren’t exactly quiet. After all, they’re just that: tractors. It’s normal for tractors like TYM that use a hydraulic pump. However, when should you be concerned about the noise you’re hearing?

Although some noise is normal, it shouldn’t be excessive. If you’re hearing a higher pitched whining noise that seems constant while you’re driving the tractor, you might want to take a look at the transmission.

There are a few reasons why your tractor has a noisy transmission system. If you’ve had the tractor for a long time, it might not come to you as much of a surprise. The more you use your tractor, the more it gets worn down, including the transmission system. If you ignore the noisy transmission issue, it could lead to axle problems. In order to fix this, you’ll want to replace any faulty or worn-down transmission parts.

Another reason you might be hearing noise involves the drive axle components. If too much air gets into these parts, the result will be lots of noise. If you haven’t changed your drive fluid in a while, now is the time to do so.

Whatever your TYM tractor problem is, rest assured that you’re not the only one experiencing problems. With some careful research, skill, and a little luck, you’ll be able to fix these issues by yourself without the need to get the tractor serviced.